Food Establishment Inspection Report
Page 1  of ????????? 
KANKAKEE COUNTY HEALTH DEPARTMENT
 2390 W. Station Street
Kankakee, IL 60901
Phone: (815) 802 - 9410
Establishment
 ANA'S RESTAURANT 		License/Permit #
 KK479
Street Address
880 W STATION ST
City/State
 KANKAKEE, IL 		ZIP Code
 60901
No. of Risk Factor/Intervention Violations 1
No. of Repeat Risk Factor/Intervention Violations 0
Date 05/15/2023
Time In 01:30 PM
Time Out 03:00 PM
Permit Holder
MEDINA, RUBEN 		Risk Category
H
Purpose of Inspection
ORIGINAL INSPECTION

FOODBORNE ILLNESS RISK FACTORS AND PUBLIC HEALTH INTERVENTIONS
Circle designated compliance status (IN, OUT, N/O, N/A) for each numbered item
IN=in compliance    OUT=not in compliance    N/O=not observed    N/A=not applicable
Mark "X" in appropriate box for COS and/or R
COS=corrected on-site during inspection    R=repeat violation 		Risk factors are important practices or procedures identified as the most prevalent contributing factors of foodborne illness or injury. Public health interventions are control measures to prevent foodborne illness or injury.
Compliance Status
 COS R

SUPERVISION

 
1 IN OUT     Person in charge present, demonstrates knowledge, and performs duties    
2 IN OUT N/A   Certified Food Protection Manager    

EMPLOYEE HEALTH

 
3 IN OUT     Management, food employee and conditional employee; knowledge, responsibilities and reporting    
4 IN OUT     Proper use of restriction and exclusion    
5 IN OUT     Procedures for responding to vomiting and diarrheal events    

GOOD HYGIENIC PRACTICES

 
6 IN OUT   N/O Proper eating, tasting, drinking, or tobacco use    
7 IN OUT   N/O No discharge from eyes, nose, and mouth    

PREVENTING CONTAMINATION BY HANDS

 
8 IN OUT   N/O Hands clean & properly washed    
9 IN OUT N/A N/O No bare hand contact with RTE food or a pre-approved alternative procedure properly allowed    
10 IN OUT     Adequate handwashing sinks properly supplied and accessible    

APPROVED SOURCE

 
11 IN OUT     Food obtained from approved source    
12 IN OUT N/A N/O Food received at proper temperature    
13 IN OUT     Food in good condition, safe, & unadulterated    
14 IN OUT N/A N/O Required records available: shellstock tags, parasite destruction    
Compliance Status
 COS R

PROTECTION FROM CONTAMINATION

 
15 IN OUT N/A N/O Food separated and protected X  
16 IN OUT N/A   Food-contact surfaces: cleaned & sanitized    
17 IN OUT     Proper disposition of returned, previously served, reconditioned & unsafe food    

TIME/TEMPERATURE CONTROL FOR SAFETY

 
18 IN OUT N/A N/O Proper cooking time & temperatures    
19 IN OUT N/A N/O Proper reheating procedures for hot holding    
20 IN OUT N/A N/O Proper cooling time and temperature    
21 IN OUT N/A N/O Proper hot holding temperatures    
22 IN OUT N/A N/O Proper cold holding temperatures    
23 IN OUT N/A N/O Proper date marking and disposition    
24 IN OUT N/A N/O Time as a Public Health Control; procedures & records    

CONSUMER ADVISORY

 
25 IN OUT N/A   Consumer advisory provided for raw/undercooked food    

HIGHLY SUSCEPTIBLE POPULATIONS

 
26 IN OUT N/A   Pasteurized foods used; prohibited foods not offered    

FOOD/COLOR ADDITIVES AND TOXIC SUBSTANCES

 
27 IN OUT N/A   Food additives: approved and properly used    
28 IN OUT N/A   Toxic substances properly identified, stored, & used    

CONFORMANCE WITH APPROVED PROCEDURES

 
29 IN OUT N/A   Compliance with variance/specialized process/HACCP    

GOOD RETAIL PRACTICES
Good Retail Practices are preventative measures to control the addition of pathogens, chemicals, and physical objects into foods.
Mark "X" in appropriate box for COS and/or R      
COS
=corrected on site during inspection  
R
=repeat violation  
Compliance Status
 COS R

SAFE FOOD AND WATER

 
30   Pasteurized eggs used where required    
31   Water & ice from approved source    
32   Variance obtained for specialized processing methods    

FOOD TEMPERATURE CONTROL

 
33   Proper cooling methods used; adequate equipment for temperature control    
34   Plant food properly cooked for hot holding    
35   Approved thawing methods used    
36   Thermometers provided & accurate    

FOOD IDENTIFICATION

 
37   Food properly labeled; original container    

PREVENTION OF FOOD CONTAMINATION

 
38   Insects, rodents, & animals not present    
39 X Contamination prevented during food preparation, storage & display X  
40   Personal cleanliness    
41 X Wiping cloths: properly used & stored X  
42   Washing fruits & vegetables    

PROPER USE OF UTENSILS

 
43 X In-use utensils: properly stored X  
Compliance Status
 COS R

PROPER USE OF UTENSILS

 
44   Utensils, equipment & linens: properly stored, dried, & handled    
45   Single-use/single-service articles: properly stored & used    
46   Gloves used properly    

UTENSILS, EQUIPMENT, AND VENDING

 
47   Food & non-food contact surfaces cleanable, properly designed, constructed & used    
48   Warewashing facilities: installed, maintained & used; test strips    
49   Non-food contact surfaces clean    

PHYSICAL FACILITIES

 
50   Hot & cold water available; adequate pressure    
51   Plumbing installed; proper backflow devices    
52   Sewage & waste water properly disposed    
53   Toilet facilities: properly constructed, supplied, & cleaned    
54   Garbage & refuse properly disposed; facilities maintained    
55   Physical facilities installed, maintained & clean    
56   Adequate ventilation & lighting; designated areas used    

EMPLOYEE TRAINING

 
57   All food employees have food handler training    
58   Allergen training as required    
IOCI 17-356

Food Establishment Inspection Report
Page 2  of ?????? 
Establishments: ANA'S RESTAURANT Establishment #: KK479
Water Supply:   Public Private   Waste Water System:   Public Private
Sanitizer Type: Chemical PPM: CHLORINE: 50-200 Heat: N/A °F
CFPM Verification (name, ID#, expiration date):
ALMA DELIA ANDRADE
21681701
04/23/2025 		ANABEL MEDINA
21849637
07/17/2027 		ALEJANDRO GUTIERREZ MEDINA
21849635
07/16/2027 		MARIA MUNOZ
161515
08/18/2027

TEMPERATURE OBSERVATIONS
Item/Location
Temp
Item/Location
Temp
Item/Location
Temp
cut tomatoes; boiled potatoes; red sauce/walk-in cooler 38.00°F beef and potatoes; chicken/table-top warmers - chicken 167.00°F cut tomatoes; cooked steak/reach-in cooler/prep-table - kitchen 39.00°F
steak /reheated on grill 181.00°F /kenmore freezer - kitchen -1.00°F shrimp/avantco reach-in cooler/prep table - kitchen 38.00°F
/forty below - freezer - dry storage -1.00°F /green world freezer - dry storage -1.00°F  

OBSERVATIONS AND CORRECTIVE ACTIONS
Item
Number 		Severity Violations cited in this report must be corrected within the time frames below.
15 P 3-302.11 (A) (2): (A) FOOD shall be protected from cross contamination by:   (2) Except when combined as ingredients, separating types of raw animal FOODS from each other such as beef, FISH, lamb, pork, and POULTRY during storage, preparation, holding, and display by: (a) Using separate EQUIPMENT for each type, or (b) Arranging each type of FOOD in EQUIPMENT so that cross contamination of one type with another is prevented, and (c) Preparing each type of FOOD at different times or in separate areas.
Violation: within the walk-in cooler, raw chicken was stored next to raw beef. corrective action taken: the two products were separated--the chicken was moved to a lower shelf. COS
39 C 3-305.11 (A) (B) (C): (A) Except as specified in ¶¶ (B) and (C) of this section, FOOD shall be protected from contamination by storing the FOOD: (1) In a clean, dry location; (2) Where it is not exposed to splash, dust, or other contamination; and (3) At least 15 cm (6 inches) above the floor. (B) FOOD in packages and working containers may be stored less than 15 cm (6 inches) above the floor on case lot handling EQUIPMENT as specified under § 4-204.122. (C) Pressurized BEVERAGE containers, cased FOOD in waterproof containers such as bottles or cans, and milk containers in plastic crates may be stored on a floor that is clean and not exposed to floor moisture.
violation: several food products within the walk-in cooler did not have overhead production, such as a container of prepped tomatoes, a container of red sauce, and a container of prepped potatoes. corrective action taken: all food items were covered it a lid or saran wrap. COS
39 C 3-305.11 (A) (B) (C): (A) Except as specified in ¶¶ (B) and (C) of this section, FOOD shall be protected from contamination by storing the FOOD: (1) In a clean, dry location; (2) Where it is not exposed to splash, dust, or other contamination; and (3) At least 15 cm (6 inches) above the floor. (B) FOOD in packages and working containers may be stored less than 15 cm (6 inches) above the floor on case lot handling EQUIPMENT as specified under § 4-204.122. (C) Pressurized BEVERAGE containers, cased FOOD in waterproof containers such as bottles or cans, and milk containers in plastic crates may be stored on a floor that is clean and not exposed to floor moisture.
violation: within the dry storage area/corridor, bags of rice, beans, and flour were found stored on the floor. corrective action taken: the food products were stored on shelves. COS
41 C 3-304.14 (B)(1)(2): (B) Cloths in-use for wiping counters and other EQUIPMENT surfaces shall be: (1) Held between uses in a chemical sanitizer solution at a concentration specified under § 4-501.114; and (2) Laundered daily as specified under ¶ 4-802.11(D).
violation: chlorine sanitizer tested at 200 PPM. corrective action taken: the sanitizer solution was remade and the chlorine concentration was reduced to 50 PPM. COS
43 C 3-304.12 (E): During pauses in FOOD preparation or dispensing, FOOD preparation and dispensing UTENSILS shall be stored: (E) In a clean, protected location if the UTENSILS, such as ice scoops, are used only with a FOOD that is not TIME/TEMPERATURE CONTROL FOR SAFETY FOOD.
violation: ice scoop was found stored within the ice bin. corrective action taken: the ice scoop was placed on a holder that stored the scoop out of the ice. COS
HACCP Topic: PROPER REHEATING PROCEDURES: REHEAT PREVIOUSLY COOKED FOOD ITEMS TO 165F (MINIMUM) AND ONLY REHEAT ONE TIME.
 

Person In Charge

  RUBEN MEDINA 		 

Date:

  05/15/2023
 

Inspector

  Alan Hatia 		 

Follow-up:  Yes   No   Follow-up Date: